Have a friend w a brand new 6.3 merc and starting in June she overheats w antifreeze in the block. Run it w 100% water and she runs about 6deg hotter than the SB motor. He has replaced everything from hoses to sensors and all pumps with new and over from other motor and still with antifreeze it...
Recently removed my gas generator, electrical side is in perfect working order short block needs a complete rebuild. $1k takes the whole thing. From what I can gather electrical side alone runs over $1k to buy by itself.
has anyone had an issue with a clacking noise happing right as the motor fires up. i replaced the starter on my SB motor and though i had broken teeth on the flywheel, after inspection definitely no broken teeth. Sounds like arching so maybe a bad coil pack? any thoughts before I start throwing...
removed my dead generator thanks to water in number 2 cylinder. parting out what is in working conditions, reach out if you need something i may have.
westerbeke 5kwbgc/gas with 221hrs
Had to rewire the helm with toggles do to faulty pads and EIMs, all done but I am having trouble with the windless. I have identified the wiring but I cant figure out which pair turned power on and which pair runs the motor. 2 are under the helm which I am guessing are the power and 3 are in the...
2002 320,
my SB switch is completely dead, indicator lights flash when powered up and thats it
port switch allows trim tabs, lift down and blower to operate only
have 13v at EIM terminals and 13v at quick connect for switches. pulled the dead switch apart and i do receive 13v power and 4.33v on...
2002/320 w 350 Mercs. when I was on a trip over the 4th everything was running fine at cruise, backed off throttle for a few minutes and my one of my engines would not go over 3000 rpm with no alarms. Changed the fuel filters ran great again for two cruises then it happened again when I came of...
Looking for some thoughts before I rip apart the entire fuel system. Yesterday coming through some snotty weather I started to get an alarm beep. Everything ran fine but continued to beep for the last 30 min home. when I put her in idle the starboard engine would not sync up unless I gave it a...
big trouble or something simple??? sooooooo i was supposed to be getting hauled in today and as normal I go to start engines one more time before pick up and nothing form my port side. Cranks but wont turn over then boom, blew the exhaust hose off from riser to muff and saw a spark from what...
So dragging my mouse around figuring out what flushing system I want to install on my recently purchased 320 V drive, I have figured out that the pervious owner had the Quicksilver coastal flushing kit installed. I can not find any information on how this system works. Does anyone use this and...
Recently purchased a 2002 320DA and have a forward and aft accessory button and Acc 1 , Acc 2 buttons and can not find what they power. Are these for options that where not included or do they actually control something? Thanks for any replies.