Ok just realize the 145.2 on my
original post was the hours!
So just ran generator again and ran for about 10 mins and shut down with an “overload” code. Checked the manual (thanks mdolesh).
Overload
Power Limit Warning
An overload condition exists when the controller senses the...
Thanks for sharing the service manual mdolesh - So the check engine fault seems to indicate a fuel issue. But the generator starts fine just stops after about 10 minutes.
Hi - I have been trying to resolve issues with this generator the past two years. I had the generator running for about 12 minutes and it shut down and it has a "145.2 Fault Check Engine" code. Does anyone have access to service manual that would identify the issues related to this code? Thanks...
So here's the update - fuel cooler needed to be cleaned out and fuel filter changed - seems like I had the issue with the paint peeling in the cooler and clogging things up. That work was done but there were also two fouled spark plugs. Unfortunately the marina that does my service is about 30...
Thanks Karl - funny the service manager said that’s he was going to start with the fuel coolers next. Do the engine misfire warnings give a specific code that identifies the underlying issue?
Good question. No vibration. Yes it is impacting performance. Struggles to get on plane especially with a load. But once on plane can achieve WOT. Yes have a engine misfire warning. Had the misfire warning for a couple weeks with no impact on performance. Talked to the place that does my...
When getting up on plane the port engine will stop at 3,000 RPMs even at full throttle. Starboard RPMs advance normally. Once on plane the Port engine will go above 3,000 and catch up to starboard. Just started doing this. Engines are regularly services at beginning of season - full time ups...
2013 330 Sundancer Twin 350 Mercury Mags
When getting up on plane the port engine will stop at 3,000 RPMs even at full throttle. Starboard RPMs advance normally. Once on plane the Port engine will go above 3,000 and catch up to starboard. Just started doing this. Engines are regularly services...
Ready to put an offer in on a 2012 Sundancer 330. Love the layout of the boat. Just one question- doesn’t seem there’s adequate cold storage for beer, waters, etc. the onboard refrigerators are pretty small and there’s absolutely no room for a cooler anywhere. Would appreciate any advice for...