Search results

I have a 34’ SeaRay with a Lofrans Progress 1 windless. A stud fell off the motor and the lower, inner clutch key way is messed up. Trying to determine whether I should buy a new windless and which model to buy that won’t mess up the deck. I have 5/16” G4 chain, no rope. Thanks John

Thanks Cliff for such a personal response, that was the kind of information I was looking for and the cocktail cruises sound great. Unfortunately we are right on Lake Erie and except for the channel, we are at cruising speed most of the time and I'd like to tone down the noise a bit so I don't...

Thanks Cliff, do you know if it's possible to run a 4 blade prop on this boat, every SeaRay in my part of the marina, has a 4 blade prop. I've also heard from another boater with that boat prop combination that he cruises at 4200 rpm's and complained about noise and vibration. Thanks again for...

I have a 2001 34' SeaRay Sundancer with the 6.2 320hp engines, tunnel drives, does anyone know the correct props for this boat. 3 blades or 4, diameter and pitch. Any info would be greatly appreciated.

I have a 2001 340 Sundancer 6.2’s and it’s revving high when on plane, over 4200 rpm’s. I have 17L19 L-Cup NI NyTorq props and I’m thinking there to small. Can someone with the same type of boat tell me what size of props there running and the rpm’s. Thanks John

I bench tested the fuel pump and it was over 55 pounds pressure when it started to stall, so the fuel pumps not the problem it's got to be the fuel pressure regulator. The regulator is $274 here in Canada does anyone have a part number for an alternative unit that would match. Thanks John

Does anyone know where I could get a manual for this Promatic 30-3 ALLTECH SERIES charger? I think it's frying my batteries. Any recommendations on a replacement would be appreciated.

I broke down and purchased the cool fuel kit from Mercury and was very disappointed, all I got was a pump, the cooling tube and a bunch O-rings. The dealer thought I would've got the fuel pressure regulator, since it was listed as a kit. I though I'd get the whole box assembly. I installed it...

I put my fuel gauge on the fuel line coming directly from the pump and it's losing pressure at that point, I'm going to put a new cool fuel box on, which will give me a pump and regulator, hopefully that will fix it. Pulling the fuel injectors off and cleaning them had no effect at all. If this...

I've pulled the injectors out, checked them with the ohm meter, there all within .1 ohms. Flushed them with carb cleaner backwards and forwards, they all spray and switch fine. I was getting a drop in pressure on the fuel rail, before I pulled them, of 1lb. every 4 minutes, this is the same on...

In the water, it will rev higher with no load.

I checked the pressure at the rail and only had 22 psi, I didn't notice the pressure dropping when I was there, I'm going back to do more testing. I'll check that part number out with my marine supplier, he said the Mercury pump was discontinued and replaced with the entire kit. Thought it may...

I've got a problem with my port engine since it came out of winter storage. It seems to run fine until you try to power up, to get in a plane and I'm only getting 3000 RPMs. I've changed the fuel filters the mechanic put his computer on it and it didn't show any codes. Change the distributor...

Just bought a 38' SeaRay Diesel engines 800 hours . Had a full survey done and had the diesel mechanics do the thousand hour engine maintenance, all fluids, belts and hoses. One hour in the ocean and fluid came out of the top of the port pod drive. Color indicates it's been mixed with a...

Came back in the marina and one of my engines wouldn't idle down, was at 2000 rpm. Checked everything mechanical seems fine and I can't get it to do it again. Has anyone had this happen? All the Marine mechanics I talked to had no ideas. Thanks John

I have a 2001 Sundancer with inboards, low hours and I'm having a problem starting the port engine, it won't turn over. So far I've always been able to start it but it's getting worse. I've moved the shifter back and forth and it didn't seem to help it. Does anyone know where the neutral safety...

I have to winterize my own boat engines this fall. The SeaRay manual says see Merc manual, which I don't have. The boat is a 2001 34' with Merc 6.2 engines. Does anyone have a manual they want to sell? Does anyone know how to winterize the oil coolers on the bottom of the engines? Any help...

RayMarine Raynav 300 GPS Plotter and Antenna, good condition, removed from my 34' SeaRay. Missing the antenna cable, could not get it free from the wiring harness, but I have both the ends. Asking $80.00

Clarion Marine stereo model XMD1, 6 disc CD changer model XM665, and remote in very good condition. Upgraded my stereo and took this out of my 34' SeaRay. I'm missing the cable for the remote, I could not get it separated from the wiring harness. Asking $100.00

I really appreciate all the information everyone has shared. I know I'm going to pay a lot more attention to the weather. We where a long ways to shore and a lightning strike could have taken all three of us out. Thanks John